Product ID:PREP RITE
MSDS Date:10/13/1997
FSC:6850
NIIN:01-454-6500
Status Code:A
MSDS Number: CJDQP

Emergency Phone: 800-535-5053

Info Phone: 800-886-8240/770-621-8240

Cage: 0WU71

Telephone: 800-886-8240/770-621-8240

Cage: 0WU71

N-METHYL-2-PYRROLIDONE

CAS: 872-50-4

RTECS: UY5790000

TRIETHANOLAMINE

CAS: 102-71-6

RTECS: KL9275000

ACGIH TLV: 5 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INGESTION-NO EFFECTS OF EXPOSURE
EXPECTED. INHALATION-PALLOR, NAUSEA, LACK OF COORDINATION, STUPOR.
EYES-VAPORS SLIGHTLY UNCOMFORTABLE, SPLASHES IRRITATING. WILL CAUSE
PAINFUL BURNING OR STINGING OF E YES AND LIDS, WATERING EYES AND
INFLAMMATION ON CONJUNCTIVA. SKIN-MAY CAUSE SEVERE DERMATITIS ON
REPEATED OR PROLONGED CONTACT.
Effects of Overexposure:SKIN-BLISTERS, CRACKING, EDEMA, REDNESS.

First Aid:INGESTION-INDUCE VOMITING IMMEDIATELY BY GIVING TWO GLASSES
OF WATER AND STICKING FINGER DOWN THROAT. INHALATION-REMOVE TO
FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN, IF BREATHING
STOPPED, GIVE ARTIFICIAL RESPIRATION AND CALL PHYSICIAN.
EYES-IRRIGATE IMMEDIATELY WITH WATER FOR AT LEAST 15 MIN. CALL
PHYSICIAN. SKIN-WASH OFF IN FLOWING WATER OR SHOWER USING SOAP AND
WATER. REMOVE CONTAMINATED CLOTHING CLOTHING AND WASH BEFORE
REUSE.

Flash Point Method:TCC
Flash Point:=93.3C, 200.F
Lower Limits:N/DETERMINED
Upper Limits:N/DETERMINED
Extinguishing Media:WATER SPRAY, ALCOHOL FOAM, DRY CHEMICAL OR CARBON
DIOXIDE
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR POSITIVE PRESSURE,
SCBA W/FULL FACEPIECE. COOL FIRE EXPO CNTNR WITH H20 SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. DANGEROUS FIRE HAZARD
WHEN EXPOSED TO HEAT OR FLAME.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION! ABSORB LIQUID
WITH EARTH, SAND OR SIMILIAR INERT MATERIAL AND DISPOSE OF WITH
SOLID WASTE ACCORDING TO FEDERAL, STATE AND LOCAL REGULATIONS.
FLUSH SPILL AREA WITH WATER .

Handling and Storage Precautions:AVOID CONTACT WITH EYES AND SKIN. KEEP
CONTAINER AND VAPORS AWAY FROM HEAT AND FLAME. KEEP CONTAINER
CLOSED WHEN NOT IN USE.
Other Precautions:WASH THOROUGHLY AFTER HANDFLING. AVOID BREATHING MIST
OR VAPORS. USE WITH ADEQUATE VENTILATION.

Respiratory Protection:NONE REQUIRED UNDRE NORMAL USE CONDITIONS.
Ventilation:LOCAL EXHAUST/HOOD OR FAN MAY BE USED. SET TO MAINTAIN
BELOW TLV. MECHANICAL/NONE REQUIRED.
Protective Gloves:IMPERVIOUS GLOVES ARE RECOMMENDED.
Eye Protection:CHEMICAL GOGGLES ARE RECOMMENDED.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:USE WITH ADEQUATE VENTILATION. WASH HANDS AFTER
USE.
Supplemental Safety and Health
WASH EQUIPMENT WITH STEAM OR WARM WATER UNTIL CLEAN.

HCC:V5
Boiling Pt:=93.3C, 200.F
Melt/Freeze Pt:M.P/F.P Text:NONE TO -20C
Vapor Pres:<1.0 MMHG
Vapor Density:AIR=1:>3.0
Spec Gravity:H20=1: 1.03
Evaporation Rate & Reference:<(N-BUACE=1)
Solubility in Water:COMPLETE
Appearance and Odor:THICK CLEAR LIQUID, SWEET ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING OR REDUCING AGENTS.
Stability Condition to Avoid:HEAT, FIRE, IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, SMOKE.

Waste Disposal Methods:THIS MATERIAL SHOULD BE DISPOSE OF IN COMPLIANCE
WITH STATE AND FEDERAL REGULATIONS.

Transport Information:NOT REGULATED.

SARA Title III Information:N-METHYL-2-PYRROLIDONE IS REPORTABLE UNDER
SARA TITLE III SECTION 313.
Federal Regulatory Information:RCRA REGULATED: YES. RCRA#D001. ALL
MATERIALS IN PRODUCT ARE TSCA LISTED. CERCLA SUPERFUND: NOT
APPLICABLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.